Weekend Recipe: Tennessee Pulled Pork Sandwiches
Shredding pork by hand is all part of the fun of making pulled pork, but to save time while getting the meat finely shredded, Cook's Country uses a stand mixer. And if you prefer a Carolina-style vinegar-based recipe you can find it here. Even better, why not make both and compare them side by side?
To assemble the sandwiches, use homemade hoecakes or hamburger buns. We suggest the former, cooked in bacon grease, to give your sandwiches an extra porky flavor. Serve with dill pickles and coleslaw.
Tennessee Pulled Pork Sandwiches
Serves 8
The roast must be seasoned at least 18 hours before cooking. Shred the pork while it's still hot. Leftover pork can be refrigerated for up to three days.
Pork
1 (5- to 6-pound) bone-in pork butt roast, trimmed
Kosher salt
2 cups wood chips
1 (13 by 9-inch) disposable aluminum roasting pan
Barbecue Sauce
1 cup ketchup
1/4 cup cider vinegar
1/4 cup water
2 tablespoons yellow mustard
1 tablespoon Worcestershire sauce
1 teaspoon granulated garlic
1 teaspoon pepper
Sandwiches
1 recipe Hoecakes
For the pork: Using sharp knife, cut 1-inch crosshatch pattern about 1/4 inch deep in fat cap of roast, being careful not to cut into meat. Pat roast dry with paper towels. Place roast on large sheet of plastic wrap and rub 2 tablespoons salt over entire roast and into slits. Wrap tightly with plastic and refrigerate for 18 to 24 hours.
Just before grilling, soak wood chips in water for 15 minutes, then drain. Using large piece of heavy-duty aluminum foil, wrap soaked chips in foil packet and cut several vent holes in top.
For a charcoal grill: Open bottom vent completely. Light large chimney starter three-quarters filled with charcoal briquettes (4 1/2 quarts). When top coals are partially covered with ash, pour evenly over half of grill. Place wood chip packet on coals. Set cooking grate in place, cover, and open lid vent completely. Heat grill until hot and wood chips are smoking, about 5 minutes.
For a gas grill: Remove cooking grate and place wood chip packet directly on primary burner. Set cooking grate in place, turn all burners to high, cover, and heat grill until hot and wood chips are smoking, about 15 minutes. Turn primary burner to medium-high and turn off other burner(s). (Adjust primary burner as needed to maintain grill temperature of 300 degrees.)
Unwrap pork and place fat side down in disposable pan. Place disposable pan on cooler side of grill. Cover grill (with lid vent directly over pork for charcoal) and cook until pork registers 120 degrees, about 2 hours. Thirty minutes before pork comes off grill, adjust oven rack to middle position and heat oven to 300 degrees.
Transfer disposable pan from grill to rimmed baking sheet. Cover pan tightly with foil and transfer to oven (still on sheet). Cook until fork inserted in pork meets little resistance and meat registers 210 degrees, about 3 hours.
For the barbecue: Meanwhile, combine all ingredients in medium saucepan and bring to boil over medium-high heat. Reduce heat to medium-low and simmer, whisking constantly, until slightly thickened, about 3 minutes. Transfer sauce to bowl and let cool completely.
Carefully remove foil from disposable pan (steam will escape). Remove blade bone from roast using tongs. Immediately transfer hot pork to bowl of stand mixer fitted with paddle attachment. Strain accumulated juices from pan through fine-mesh strainer set over separate bowl; discard solids.
Mix pork on low speed until meat is finely shredded, about 1 1/2 minutes. Whisk pork juices to recombine, if separated, and add 1 1/2 cups juices to shredded pork. Continue to mix pork on low speed until juices are incorporated, about 15 seconds longer. Season with salt to taste, adding more pork juices if desired. Serve pork on hoecakes with barbecue sauce, pickles, and coleslaw.
